| |
| |
|
Motorcycles Information |
|
|
|
How to Remove Your Mk2 Mini Moto Engine
Many mini moto modifications will require you to remove the engine from the mini moto. This is why I have produced the following guide. Firstly you will need to remove the mini moto's fairing. Start with the seat fairing, unscrew the four seat screws and remove the seat. Unscrew the screw at the front end of the seat fairing and remove the petrol cap. The fairing can now be lifted from the mini moto. Replace the fuel tank petrol cap and remove the fuel tank by pulling the rubber tube of the nipple on the top of the carburettor. You may want to double the rubber fuel tube over and secure it in this position with a clothes peg. This is to stop fuel leaking out. Remove the bottom fairing by unscrewing the holding bolts (two on each side), this frees the bottom fairing from the top. Unscrew the two bolts on the underside of the bottom fairing. The bottom fairing is now free. The top fairing is only now held on by one last bolt located in between the handle bars at the front of the mini moto. Once you have removed the fairing, you will need to take the chain off the front sprocket. To do this loosen the back wheel nuts and the tensioning bolts. The back wheel can now be manoeuvred toward the front sprocket loosing the chain. When the chain is loose enough you can remove it from the front sprocket. Remove the pull start from the engine by unscrewing the three holding screws. Once the pull start has been removed you will see the wire that comes from the stop switch. Unplug this. The throttle cable can be removed from its fitting on the top of the carburettor. Pull the rubber seal up so that the locking nut can be unscrewed, the throttle can now be pulled from the carburettor along with the needle valve and spring. The next step is to Remove the Exhaust. The exhaust is fixed to the mini motos frame by a bolt located just under the seat fairing toward the back of your mini moto. Undo this bolt with a spanner and an alan key. The exhaust is fixed to the underside of the engine by two bolts via a gasket. Remove the two bolts with an alan key making sure that you do not lose the gasket washer. The exhaust can now be slid out past the engine and removed form the mini moto. The engine is free from its mechanical fittings, the engine then needs to be removed from the mini motos frame. The bolt at the top of the engine must be undone first using the alan key. The three screws located on the underside of the engine are the last fixings to be undone. The engine can now be completely removed from the mini moto. Matt Tong has been importing and riding Mini Motos for two years. For expert advice and Mini Moto information please visit http://www.minimotosandmore.com
MORE RESOURCES:
Google News |
|
|
|
RELATED ARTICLES
The Buzz is All About Mini-Motorcycles Pocket bikes are miniature motorcycles -- powered, for the most part, by oil- and gas-burning engines similar to those used in chain saws, weed whackers or other small motorized tools -- and they look just like the real thing.The snazziest models cost thousands and are made in Italy, but the ones that are selling by the container load run from $200 to $500. Personal Scooters are Not Just for Fun Personal scooters are a highly valuable mobility tool for those who, for health reasons, are unable to move around in public or in their own homes. They can ease the burden of having to carry things like heavy groceries or other personal effects. Auctions and Car Transport: Everything You Need To Know Everyone has wanted to sell a car at some point and in the age of Internet auctions, there are more options than ever when it comes to selling your car whether it's an '05, '78 or a '20. With this ever expanding world of options comes the need to make delivery after you've sold the vehicle and that requires a car transport service. Common Mistakes Motorcycle Buyers Make When Looking For a Motorcycle Loan Whether interest rates are high or low or it's the end of a model year with lots of incentives, motorcycle buyers tend to make the same mistakes when shopping for a motorcycle loan. Here are four common mistakes motorcycle buyers make with motorcycle loans. Motorcycle Parts - OEM or Aftermarket ? This is always a difficult one to answer when shopping for motorcycle parts and I firmly believe that each one of us must decide what's best for our bikes AFTER carefully evaluating each of the possibilities.For me?Well. Motorcycle Protective Clothing That Works! There is some great looking motorcycle clothing on the market these days, but believe me not all of the motorcycle clothing offers as much protection as you think. In Europe, for motorcycle clothing to be lawfully sold as "safety" clothing, it has to pass a series of European standards, which are pretty lengthy but are available on my website. Ride Hard - Hydrate Harder This summer is showing all of the signs of being a hot one. Temps have already been hitting the 100's here in the Midwest. Workings of a Motorcycle Muffler Suspension Motorcycles are becoming more popular because of its convenience and relatively inexpensive cost compared to automobiles. They are capable of the same speeds as cars and can also be licensed for use on public highways. Motorcycle Accidents: Preparing Your Case Motorcycle accident is an unexpected occurrence that results to shock and trauma, serious physical injuries and death. The most common reason of a motorcycle accident, which contributed to the 50% of the motorcycle vehicle, is due to the failure of another motorist to see the motorcycle. Avoiding Excessive or Uneven Front Tire Wear All rubber tires wear down over time, whether they're on a motorcycle or automobile. However, you want to watch out for uneven or excessive wear, both of which can cause serious problems for motorcycle riders. How To Make Your Own Vintage Motor Cycle & Automotive Spare Parts Vintage Car & Motorcycle restoration enthusiasts all share one thing in common.. Welcome To The World Of "Upside Down" Motorcycle Loans! With the depreciation on motorcycles being so enormous after they are driven off the showroom floor, the potential for a buyer owing more on their motorcycle loan than the bike is worth it quite high. Owing more on your bike than it is worth is often referred to as the world of "up side down". The Motorcycle Helmet You Want May Not Be As Safe As You Think! Choosing the right Motorcycle helmet can make a difference?.?. It's One Thing for People to Buy Your Product or Service, but It's Another for Them to Tattoo Your William Harley and Arthur Davidson, both in their early twenties, built their first motorcycle in 1903. During their first year, the company's entire output was only 1 motorbike; however, by 1910, the company had sold 3,200. Necessity of Motorcycle Parts If you are one of the many people who consider your bike as invaluable as your family, then we know you're head over heels. We may be judged heavily for this perception but you might even be willing to dump your partner just so you could spend time riding and caring for your bike? though, we hope you are not that obsessed. So You Want To Be A Custom Bike Builder? Start With A Motorcycle Kit! So you want to be a custom bike builder? Well friend, before you rush out and buy that motorcycle kit, the one that will set you on the road to riches and fame, stop and think about the level of expertise and artistry the top builders have attained. More importantly think about how long it has taken them to attain it! Let's look at a few key issues?EducationYou'd be surprised how well educated a lot of today's top bike builders are. Suzuki Motorcycles - From Fine Loom Manufacturers to Major Motorcycle Company Started in a small warehouse by Michio Suzuki back in 1909, Suzuki aimed at making better looms for the Japanese silk industry. It was only thirty years after its existence that the company started thinking of diversifying into cars, motorcycles and related machinery. 0 to 60 in 4.5 Seconds Speeding is illegal, yet we sell racing motorcycles and cars which are so powerful and look so intimidating that a police man could write the owner a ticket even if it were parked. Take today's crotch rocket, nearly all of these motorcycles can barely get out of second or third gear going sixty miles per hour. A Convenient Way to Slash Your Gas Bill "With oil prices spiraling higher almost every day, people are starting to look for alternative modes of transport," says Michael S. Milstead of Scootertronics. Women and Motorcycles? You Bet! To really understand the women and her ride, one needs to go back in history to explore the courageous women who defied the norm and road their horses in the freedom of the wind. Who could forget Joan of Arc or Annie Oakley.
|
| home | site map |
| © 2006 |
